6 recalls found. |
DEFECT #1 - SUSPENSION
Posted on: 2001-11-05
Description
Vehicle description: school buses equipped with hendrickson rear air suspension. Inadequate tightening of the 5/8 bolts on the rear air suspension hanger bolts and on rear axle torque arm axle seat studs.
Consequence
Insufficient tightening permits movement between the components that could result in bolts and studs breaking, increasing the risk of a crash.
Corrective Action
Dealers will replace the 5/8 grade 8-hanger bolts. In addition, axle spring seat fasteners will be checked for proper tightness and, if needed, tightened to specifications. Owner notification began january 18, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-478-822-2242.
Notes
Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - ELECTRICAL SYSTEM:WIRING
Posted on: 2001-06-14
Description
Vehicle description: school and transit buses equipped with rear mounted engines. The 12-volt power supply cable(s) may be chaffed by hoses, harnesses, frame components, or clamps.
Consequence
This condition can result in power failure and/or risk of fire in the engine compartment.
Corrective Action
Dealers will remove and inspect the 12-volt power cable(s) from the battery to the starter and, if necessary, will replace the cables. Owner notification began july 30, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1-912-822-2242.
Notes
Blue bird recall no. R01ff.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - SERVICE BRAKES, AIR:ANTILOCK
Posted on: 2001-01-26
Description
Vehicle description: transit and school buses equipped with meritor wabco phase 1, d-version antilock brake system (abs), fail to comply to the requirements of fmvss no. 105, hydraulic and electric brake systems. An internal diagnostic system in the abs may not detect an extreme wheel speed sensor air gap. Such a condition could possibly occur during (1) original assembly or (2) subsequent wheel end service.
Consequence
Failure of the electronic control unit to detect an extreme wheel speed sensor air gap can result in the loss of antilock braking function on the wheel(s) where the air gap exists, increasing the risk of a crash.
Corrective Action
The abs ecu will be removed and replaced or the ecu will be reprogrammed.
Notes
Owner notification began february 12, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at. Also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #4 - EQUIPMENT ADAPTIVE
Posted on: 2004-08-31
Description
Certain blue bird 1999-2005 all american, tc/2000, micro bird, vision, conventional, and commercial series school buses equipped with sure-loc wheelchair securement systems and manufactured between february 17, 1999, and august 13, 2004. Certain sure-lok wheelchair tie-down securement assemblies p/n 8625-13. The sprocket teeth of the retractor assembly may be out of alignment causing the load pawl not to fully seat in the sprocket teeth.
Consequence
In the event of a vehicle crash, the wheelchair may not be adequately secured possibly resulting in injuries.
Corrective Action
Blue bird will notify its customers and replace the defective part free of charge. The recall began september 21, 2004. Owners who take their buses to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact at blue bird at 478-822-2242.
Notes
Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #5 - VEHICLE SPEED CONTROL
Posted on: 2005-04-15
Description
Certain 2001 through 2005 all american, commercial series, and q-bus school and transit buses equipped with john deere 8.1 cng engines. The subject buses equipped with the john deere engines may surge inappropriately due to erractic operation of the air throttle if the engine is taken from full to zero load.
Consequence
Unexpected engine surge could result in a vehicle crash, possibly resulting in personal injury.
Corrective Action
John deere will notify blue bird's customers and repair the engines free of charge. Customers are being instructed to contact john deere at 1-800-jd-engine.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #6 - FUEL SYSTEM, DIESEL
Posted on: 2005-02-28
Description
Certain 1998 through 2002 blue bird all american, tc2000 school and transit buses, and commercial series buses equipped with cummins isb diesel engines. The fuel pump could fail to transfer fuel appropriately creating an engine stall condition.
Consequence
Should the engine stall while the vehicle is in use, a possible vehicle crash could occur.
Corrective Action
Customers will be notified by cummins to bring their vehicles to an authorized dealer to have the fuel lift pump replaced free of charge. For more information, customers may contact cummins at 1-800-diesels.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.