Recalls for 2001 Crane Ldt

DEFECT #1 - SERVICE BRAKES, AIR:SLACK ADJUSTERS:AUTOMATIC

Posted on: 2003-06-09
Description
On certain trailers equipped with a specific combination of reyco suspension, eaton drive axle, and bendix slack adjusters, the failure of a drive axle slack adjuster to automatically adjust as required to compensate for brake wear, will cause an out of adjustment condition.  If this condition occurs and is not identified and corrected through normal inspections and maintenance, the slack adjuster will over-rotate and may contact the suspension lower spring saddle.  

Consequence
If this occurs, braking performance will be inhibited, increasing the risk of a crash without warning.  

Corrective Action
Crane carrier will supply, at no charge, gunite slack adjusters and installation instructions to replace the existing bendix slack adjusters on the drive axle.  The installing facility will be reimbursed by crane for one (1) hour labor per vehicle at their posted labor rate.  Owner notification began on june 10, 2003.  Owners should contact crane at 1-918-832-7305.

Notes
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).

DEFECT #2 - SERVICE BRAKES, AIR

Posted on: 2008-02-01
Description
Crane carrier is recalling 672 my 1999-2001 coe,my 1999-2002 ldt, my 2001-2007 ldt2, my 1998-2003 let, and my 2001-2007 let2 refuse cab and chassis for failing to comply with the brake release timing requirements of federal motor vehicle safety standard no.  121, air brake systems.  The brake release timing was slower than required.  

Consequence
This standard specifies performance and equipment requirements for vehicles equipped with air brake systems, including air-over-hydraulic brake systems, to ensure safe braking performance under normal and emergency conditions.

Corrective Action
Crane will replace several fittings and hoses which will increase the air flow and subsequently improve the brake release timing.  The recall began on march 14, 2008.  Owners may contact crane carrier at 918-832-7305.

Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.