6 recalls found. |
DEFECT #1 - PARKING BRAKE
Posted on: 2004-04-21
Description
Certain trucks fail to comply with the requirements of federal motor vehicle safety standard no. 121, air brake systems. A standard fitting was installed in place of a single check valve on the park brake relay valve.
Consequence
This could result in the parking brake not releasing and stopping the vehicle increasing the risk of a crash.
Corrective Action
Dealers will install the check valve. Owner notification began on may 3, 2004. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
Notes
International recall no. 04504.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - SEAT BELTS:FRONT:BUCKLE ASSEMBLY
Posted on: 2004-04-22
Description
Certain trucks fail to comply with the requirements of federal motor vehicle safety standard no. 209, seat belt assemblies. The seat belt latch failed a quality review.
Consequence
This could cause the seat belt latch to become disengaged without warning in a vehicle crash or during episodes of high seat belt loading.
Corrective Action
Dealers will replace the seat belt assemblies. Owner notification is began on june 11, 2004. Owners should contact international at 1-800-445-7825.
Notes
International recall no. 04506.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #3 - TRAILER HITCHES:FIFTH WHEEL ASSEMBLY
Posted on: 2005-04-29
Description
On certain vehicles equipped with air operated fifth wheel slides and an msva 7-pack accessory controller, the 7-pack can allow water to contaminate its circuit board. This could result in inadvertent operation of the fifth wheel slide control.
Consequence
If the slide control actuates while the vehicle is in motion, momentum from the trailer can cause the fifth wheel to slide without input from the driver, which could result in a crash without warning.
Corrective Action
Dealers will relocate the msva 7-pack to a less water intensive environment. A new msva 7-pack base, that has been improved to prevent water intrusion, and all air accessory solenoids will be installed free of charge. The recall began on august 5, 2005. Owners may contact international at 1-800-448-7825.
Notes
International recall no.05511. Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #4 - POWER TRAIN:DRIVELINE:UNIVERSAL JOINT
Posted on: 2004-03-26
Description
On certain trucks equipped with dt466 or dt530 1308 style engines and 4x4 or 6x6 capability, the universal joint between the front drive shaft and drive axle could come in contact with the engine oil filter under certain braking conditions.
Consequence
This could cause a loss of complete engine oil which could result in the engine shutting down and increase the risk of property damage, personal injury, or a crash.
Corrective Action
Dealers will install a shorter oil filter and adapter. Owner notification is expected to begin april 29, 2004. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact international at 1-800-448-7825.
Notes
International recall no. 04504.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #5 - ELECTRICAL SYSTEM:BATTERY:CABLES
Posted on: 2004-06-30
Description
On certain heavy duty trucks equipped with international dt530, cummins, or caterpillar i-6 engines, the positive battery cable between the batteries and the starter may rub against an electrical ground cable between the starter and frame rail.
Consequence
This could cause an electrical short and/or fire.
Corrective Action
Dealers will inspect for any chafing. If there is no evidence of chafing, a saddle clamp will be installed. If there is evidence of chafing, the damaged cables will be replaced and the saddle clamp installed. The recall began on august 16, 2004. Owners should contact international at 1-800-448-7825.
Notes
International recall no. 04510. Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #6 - STRUCTURE
Posted on: 2004-12-02
Description
On certain trucks, the bolts that mount the front of the cab to the mounting brackets were not properly torqued at the manufacturing plant.
Consequence
These bolts can loosen during normal vehicle use and fall out. This may lead to the cab separating from the vehicle's chassis during a vehicle crash that may result in property damage, personal injury or death.
Corrective Action
As an interim action, dealers will properly tighten the existing cab mounting bolts and replace any missing bolts. As soon as parts are available, dealers will replace all sixteen bolts and tighten them properly. An interim letter was sent to owners on february 11, 2005. Another letter was sent to owners on april 8, 2005, as soon as parts are available. Owners should contact international at 1-800-448-7825.
Notes
International recall no. 05502 (04521 interim action).customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).