29 recalls found. |
DEFECT #1 - FUEL SYSTEM, DIESEL
Posted on: 2011-09-21
Description
Daimler trucks is recalling certain model year 2004 through 2008 heavy trucks manufactured from july 11, 2003, through september 28, 2007, equipped with epa04 model mbe4000 engines built with plastic low pressure fuel lines and fuel filters mounted near the center of the engine on the left-hand side. The plastic low pressure fuel line between engine mounted fuel filter and engine block may develop a substantial diesel fuel leak.
Consequence
This could create a road hazard increasing the risk of a crash. Fuel leakage, in the presence of an ignition source, could result in a fire.
Corrective Action
Daimler trucks will notify owners and the remedy will be performed by detroit diesel corporation authorized repair facilities. Vehicles will be inspected and the plastic low pressure fuel line will be replaced with a steel low pressure fuel line. This service will be performed free of charge. An interim letter was mailed to owners on october 28, 2011. The safety recall began on february 21, 2012. Owners may contact daimler trucks at 1-800-547-0712.
Notes
Daimler trucks' campaign number is 11c-2.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #2 - STEERING:RACK AND PINION
Posted on: 2009-09-16
Description
Daimler trucks is recalling certain model year 2005 through 2010 heavy duty trucks manufactured from october 29, 2005 through july 3, 2009. Under certain condition, the left hand inner tie rod end may loosen over time and if not corrected, potentially separate from the steering rack.
Consequence
A separated tie rod assembly can result in loss of vehicle control at higher speeds and a crash could occur.
Corrective Action
Daimler trucks will notify owners and the vehicles will be repaired free of charge. The safety recall began on february 5, 2010. Owners may contact daimler trucks toll-free at 1-800-547-0712.
Notes
Daimler trucks' recall campaign number fl-557.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #3 - AIR BAGS
Posted on: 2009-09-30
Description
Daimler trucks is recalling certain model year 2008 through 2009 trucks equipped with indiana mills and manufacturing rolltek side-roll protection systems. The sensor designed to detect vehicle roll can malfunction and cause the side airbags to inadvertently deploy.
Consequence
Inadvertent deployment of the side airbags could result in a vehicle crash or injury to an out of position occupant.
Corrective Action
Daimler trucks will inspect to determine if a vehicle contains an affected system and, if so, that system will be replaced free of charge. The recall is expected to begin on or before november 20, 2009. Owners may contact daimler trucks at 1-800-547-0712.
Notes
Damiler recall no.fl-559.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #4 - ELECTRICAL SYSTEM:BATTERY:CABLES
Posted on: 2011-06-21
Description
Dtna is recalling certain model year 2008-2012 freightliner; cascadia, century class, columbia, and coronado, certain model year 2008-2009 sterling; a-line and l-line and certain model year 2009-2012 western star constellation vehicles, manufactured from january 14, 2008, through june 15, 2011, built with detroit diesel 15 or 16 engines. The bolt attaching a rubber isolator to a support bracket may become loose and back out, potentially contacting an un-fused starter cable and creating a short circuit.
Consequence
A short circuit between an un-fused battery cable and chassis ground could result in a vehicle fire.
Corrective Action
Dealers will install a new bolt and isolator and repair the recreational vehicles free of charge. The safety recall began on december 21, 2011. Owners may contact dtna at 1-800-547-0712.
Notes
Daimler safety recall no. Fl-609.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #5 - ELECTRONIC STABILITY CONTROL
Posted on: 2011-09-08
Description
Daimler trucks is recalling certain model year 2006-2012 freightliner business class m2, cascadia, century, columbia, coronado and sterling a-line vehicles built with meritor wabco electronic stability control (esc) system manufactured from september 15, 2005 through september 1, 2011. Under certain road and driving conditions, vehicle body roll and road inclination characteristics may adversely affect the slip angle calculation of the electronic stability control (esc) system. This might cause the esc to perceive an over steering situation and therefore apply the outer wheel brake on the front axle until the vehicle is perceived to be stable.
Consequence
If the driver is slow to react during this esc intervention, the vehicle may deviate from the intended line of travel increasing the risk of a crash.
Corrective Action
Daimler trucks will notify owners, and dealers will replace the esc module with the appropriate software version as necessary, free of charge. An interim owner notification will be mailed on or about november 21, 2011. The date for availability of the final remedy is subject to validation testing and parts availability. The safety recall began on march 28, 2012. Owners may contact daimler trucks toll-free at 1-800-547-0712.
Notes
Daimler safety recall number is fl-612.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #6 - FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 2009-10-06
Description
Daimler trucks is recalling certain model year 2006 through 2010 heavy trucks manufactured between january 17, 2006 and march 31, 2009, equipped with epa07 model mbe4000 engines built with plastic low pressure fuel lines. The plastic lines may experience leaks due to fatigue cracks caused by stress and vibration combined with high internal pressure.
Consequence
If a diesel fuel leak continues undetected under certain conditions fuel may ignite on a hot engine surface and/or fuel may spill on the road increasing the risk of a crash.
Corrective Action
Daimler trucks will notify owners and the remedy will be performed by detroit diesel corporation authorized repair facilities and direct warranty customers. The safety recall began on may 7, 2010. Owners may contact daimler trucks at 1-800-547-0712.
Notes
Daimler truck's recall campaign number is 09c-2.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #7 - STEERING:GEAR BOX:SHAFT SECTOR
Posted on: 2007-12-21
Description
On certain trucks equipped with trw steering gears, models tas85 and rcs85, these steering gears contain potentially defective sector shafts with an incorrect gear tooth which may interfere with the rack-piston teeth, resulting in a stick or bind condition.
Consequence
This condition has the potential to cause the steering gear to stall and restrict the steering turning angle of the vehicle which could result in a vehicle crash.
Corrective Action
Freightliner is working with trw to replace the defective steering gear (please see 07e101). The recall began on april 18, 2008. Owners may contact freightliner at 1-800-547-0712.
Notes
Freightliner fl-519.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #8 - SERVICE BRAKES, AIR:DISC
Posted on: 2008-01-28
Description
On certain trucks and motor homes chassis, incorrect fasteners may not provide adequate clamping force between the brake caliper and brake anchor plate potentially resulting in reduced brake effectiveness.
Consequence
Reduced brake effectiveness could lead to a vehicle crash.
Corrective Action
Dealers will inspect the vehicles to determine if incorrect bolts were used. If incorrect bolts are found, vehicles will be inspected for possible additional damage and repaired as required. The recall began on june 6, 2008. Owners may contact daimler trucks north america at 1-800-547-0712.
Notes
Dtna recall no. Fl-521.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #9 - ENGINE AND ENGINE COOLING
Posted on: 2011-03-04
Description
Daimler trucks (dtna) is recalling certain model year 2006 through 2011 freightliner, cascadia, century, columbia fld, and m2, sterling 9500, and western star 4900 heavy trucks manufactured from march 20, 2006, through june 30, 2010, equipped with specific mbe4000 epa07 model engines. The intake air grid heater may short circuit and fail due to excessive internal temperatures.
Consequence
A short circuited grid heater could result in a vehicle fire and injury to vehicle occupants.
Corrective Action
Dtna will notify owners of the recall during march 2011. Another notification will be issued once the remedy is released. Dtna expects the remedy to be available by december 1, 2011. Repairs will be performed by dtna dealers free of charge. Owners may contact dtna toll-free at 1-800-547-0712. This recall is asscociated with a previous recall, campaign number 10v-341.
Notes
Daimler trucks' recall campaign number is 10c-5.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #10 - PARKING BRAKE:CONVENTIONAL:AIR
Posted on: 2008-04-09
Description
Daimler trucks is recalling 900 my 2008 freightliner argosy, argosy rhd, cascadia, columbia, century st, coronado, sterling acterra, l-line and western star 4900 trucks equipped with bendix mv-3 dash control valves. The molded valve body has an incorrect core pin in the injection mold causing the valve body to be oversized in the double check valve area. This condition can allow the rubber double check valve to become lodged in the body opening under certain circumstances.
Consequence
If the double check valve becomes lodged, in the event of a primary reservoir failure, air pressure can leak past the lodged double check valve thereby depleting the secondary reservoir, causing reduced ability for modulating the service emergency brakes increasing the risk of a crash.
Corrective Action
Dealers will inspect the mv-3 dash valve for the production date code. Valves in the affected production lots will be replaced free of charge. The recall began on october 9, 2008. Owners may contact daimler trucks at 1-800-547-0712.
Notes
Daimler recall no. Fl-528.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #11 - ENGINE AND ENGINE COOLING
Posted on: 2010-07-27
Description
Daimler trucks is recalling certain model year 2007 through 2011 freightliner, fccc, sterling, and western star heavy trucks manufactured from september 5, 2006, through june 30, 2010, equipped with specific mbe900 epa04 and epa07 model engines. The intake air grid heater may short circuit and fail due to excessive internal temperatures.
Consequence
A short circuited grid heater could result in a vehicle fire and injury to vehicle occupants.
Corrective Action
Daimler trucks will notify owners and dealers will repair the buses free of charge. Repairs will be performed by detroit diesel corporation authorized repair facilities. The safety recall is expected to begin on or about july 29, 2011. Owners may contact daimler trucks toll-free at 1-800-547-0712.
Notes
Daimler trucks' recall campaign number is 10c-5.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #12 - ELECTRICAL SYSTEM
Posted on: 2009-01-22
Description
Daimler trucks is recalling 14181 my 2007-2009 freightliner cascadia trucks equipped with cab signal-detect and activation modules (sams). Potential corrosion damage due to water intrusion into the sams may cause electrical shorts or intermittent operation of tail lamps, stop lamps, side marker lamps and trailer lighting. In some cases starter motors have activated without a key on.
Consequence
An electrical short in the cab sam or chassis sam may cause melting in the sam or other electrical components which may cause a vehicle fire.
Corrective Action
Dealers will inspect for indication of water intrusion or damage to the sams. Sams will be replaced as required and modifications will be completed to control possible sources of water intrusion. The recall is expected to begin on or before february 13, 2009. Owners may contact daimler trucks at 1-800-547-0712.
Notes
Daimler trucks recall no. Fl545.customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #13 - FUEL SYSTEM, OTHER
Posted on: 2010-05-07
Description
Daimler trucks is recalling certain model year 2008 through 2011 freightliner columbia, cascadia, coronado, century, m2, sterling 9500, and western star 4900 vehicles equipped with dd 13 and dd15/dd16 engines and manufactured from january 1, 2007 through april 5, 2010. Should the fuel filter become restricted, the low pressure fuel flange may develop a crack resulting in a fuel leak.
Consequence
Fuel leaking onto the roadway may result in vehicle crash.
Corrective Action
The low pressure fuel flange will be replaced with a more robust component. This service will be performed free of charge. The safety recall began on september 17, 2010. Owners may contact daimler trucks at 1-800-547-0712.
Notes
Daimler trucks recall no. Fl-578.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #14 - ELECTRICAL SYSTEM: SOFTWARE
Posted on: 2010-03-16
Description
Daimler trucks has notified nhtsa of a defect in certain model year 2008 through 2010 cascadia equipped with lifeguard rolltek advanced occupant protection system. The lifeguard rolltek is designed to provide additional protection to vehicle occupants in the event of a rollover accident and it may not have been properly installed.
Consequence
Reduced effectiveness of the advanced occupant protection system may increase the risk of injury.
Corrective Action
Dealers will inspect and install an additional retainers to ensure the system remains fully functional. This service will be performed free of charge. The safety recall began on august 4, 2010. Owners may contact daimler trucks at 1-800-547-0712.
Notes
Daimler recall no. Fl-573.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #15 - ENGINE AND ENGINE COOLING
Posted on: 2009-10-14
Description
Daimler trucks is recalling model year 2007-2010 freightliner, sterling and western star vehicles equipped with detroit diesel dd15 epa07 engines which were manufactured with grid heaters. Increased internal grid heater resistance caused by improperly tightened screws may melt the solder on the grid heater circuit board leading to a short circuit.
Consequence
A short-circuited grid heater could result in a vehicle fire and injury to vehicle occupants.
Corrective Action
The engine control logic will be reprogrammed free of charge by detroit diesel authorized repair facilities and direct warranty customers to provide cold weather starting without the need of a grid heater. The safety recall began on november 4, 2009. Owners may contact detroit diesel at 1-313-592-5800 and daimler trucks at 1-800-547-0712.
Notes
Daimler trucks recall no. 09c-4.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #16 - ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Posted on: 2012-02-28
Description
Daimler trucks (dtna) is recalling certain model year 2006-2013 freightliner, sterling, and western star vehicles, equipped with detroit diesel epa07 and epa10, dd13 and dd15/16 engines, manufactured from january 20, 2006, through february 20, 2012. The pump to rail high pressure fuel line support system used on these engines is sensitive to assembly torque and may be damaged during service work. As a result of other repairs, the line supports may loosen, potentially leading to fuel line cracking and a fuel leak.
Consequence
A fuel leak could create a road hazard, increasing the risk of a crash. Also a fuel leak in the presence of an ignition source can result in a fire.
Corrective Action
Dtna will notify owners, and where necessary, the high pressure fuel line support system will be replaced by dtna authorized service facilities, free of charge. The safety recall began on april 27, 2012. Owners may contact dtna at 1-800-547-0712.
Notes
Dtna's recall campaign number is 12c-2.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #17 - STEERING:RACK AND PINION
Posted on: 2011-10-25
Description
Daimler trucks is recalling certain model year 2005-2011 freightliner cascadia, columbia, century, coronado, and classic xl trucks manufactured from november 1, 2004, through june 15, 2010 for the rack and pinion steering system. The lower pinion bearing may corrode and fail. A failed bearing may lead to damage of the spool valve seals. A damage spool valve seal may allow hydraulic fluid to flow to the right or left turn port instead of flowing to the return port.
Consequence
The steering could unexpectedly turn left or right, making the vehicle more difficult to control and increasing the risk of a crash.
Corrective Action
Daimler trucks will inspect the lower bearing for corrosion. If corrosion is found, the rack and pinion system will be replaced. If no corrosion is found, on the bearing, the bearing will be packed with grease and the rubber bellows will be replaced with sealant added between the bellows and the rack housing. An interim letter was mailed in december 2011. Owners may contact daimler trucks toll-free at 1-800-547-0712.
Notes
Daimler trucks' safety recall number is fl-614.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #18 - ENGINE AND ENGINE COOLING:ENGINE
Posted on: 2014-02-28
Description
Daimler trucks north america llc (daimler) is recalling certain model year 2008-2015 freightliner 114sd, cascadia, m2 business class, sterling lt8500, and thomas built buses saf-t-liner hdx vehicles manufactured february 19, 2008, through february 11, 2014, and equipped with cummins westport model isl g and cummins westport model isx12 g engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.
Consequence
The sensor malfunction could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire or burn injury to a person near the exhaust pipe.
Corrective Action
Cummins and cummins westport will notify owners, and authorized cummins service facilities will upload a new ecm calibration, free of charge. The recall began on april 12, 2014. Customers may contact daimler at 1-800-385-4357 or cummins inc. At 1-800-343-7357. Daimler's number for this recall is fl-660.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #19 - ELECTRICAL SYSTEM
Posted on: 2015-03-04
Description
Daimler trucks north america llc (dtna) is recalling certain model year 2007-2011 freightliner cascadia trucks manufactured march 26, 2007, to august 31, 2010. Water may leak into the signal-detection and activation module (sam) chassis causing corrosion which may result in electrical shorts or possible intermittent operation of trailer lights.
Consequence
Intermittent operation of the trailer lights may prevent other drivers from knowing that the truck is slowing or stopping, increasing the risk of a vehicle crash. Additionally, an electrical short in the sam chassis may result in a a fire.
Corrective Action
Dtna will notify owners, and dealers will inspect the sam chassis for corrosion, replacing it as necessary. Any vehicle that does not have a drip shield mounted in the cab over the sam chassis will receive one. These repairs will be performed free of charge. An interim letter was sent to owners on may 4, 2015. The recall began on october 8, 2015. Owners may contact dtna customer service at 1-800-745-8000. Dtna's number for this recall is fl-679.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #20 - EQUIPMENT
Posted on: 2017-12-20
Description
Daimler trucks north america llc (dtna) is recalling certain 2002-2017 freightliner cascadia, century class, columbia and coronado trucks and western star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with kidde plastic-handle or push button 'pindicator' fire extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/rmisc-17e062-5427.pdf
Consequence
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Corrective Action
Dtna will notify owners, and instruct them to contact kidde for a replacement fire extinguisher, free of charge. The recall began on april 11, 2018. Owners may contact dtna customer service at 1-800-547-0712, or contact kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on product safety recall for more information. Dtna's number for this recall is fl-759.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #21 - EXTERIOR LIGHTING:BRAKE LIGHTS
Posted on: 2017-11-30
Description
Daimler trucks north america, llc (dtna) is recalling certain 2008-2018 freightliner cascadia, western star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.
Consequence
If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.
Corrective Action
Dtna will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on january 22, 2018. Owners may contact dtna customer service at 1-800-547-0712. Dtna's number for this recall is fl-756.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #22 - EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Posted on: 2017-11-30
Description
Daimler trucks north america, llc (dtna) is recalling certain 2008-2018 freightliner cascadia, western star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.
Consequence
If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.
Corrective Action
Dtna will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on january 22, 2018. Owners may contact dtna customer service at 1-800-547-0712. Dtna's number for this recall is fl-756.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #23 - EQUIPMENT
Posted on: 2017-12-20
Description
Daimler trucks north america llc (dtna) is recalling certain 2002-2017 freightliner cascadia, century class, columbia and coronado trucks and western star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with kidde plastic-handle or push button 'pindicator' fire extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/rmisc-17e062-5427.pdf
Consequence
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Corrective Action
Dtna will notify owners, and instruct them to contact kidde for a replacement fire extinguisher, free of charge. The recall began on april 11, 2018. Owners may contact dtna customer service at 1-800-547-0712, or contact kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on product safety recall for more information. Dtna's number for this recall is fl-759.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #24 - EXTERIOR LIGHTING:BRAKE LIGHTS
Posted on: 2017-11-30
Description
Daimler trucks north america, llc (dtna) is recalling certain 2008-2018 freightliner cascadia, western star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.
Consequence
If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.
Corrective Action
Dtna will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on january 22, 2018. The recall began on may 9, 2018. Owners may contact dtna customer service at 1-800-547-0712. Dtna's number for this recall is fl-756.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #25 - EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Posted on: 2017-11-30
Description
Daimler trucks north america, llc (dtna) is recalling certain 2008-2018 freightliner cascadia, western star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.
Consequence
If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.
Corrective Action
Dtna will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on january 22, 2018. The recall began on may 9, 2018. Owners may contact dtna customer service at 1-800-547-0712. Dtna's number for this recall is fl-756.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #26 - EQUIPMENT
Posted on: 2017-12-20
Description
Daimler trucks north america llc (dtna) is recalling certain 2002-2017 freightliner cascadia, century class, columbia and coronado trucks and western star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with kidde plastic-handle or push button 'pindicator' fire extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/rmisc-17e062-5427.pdf
Consequence
In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.
Corrective Action
Dtna will notify owners, and instruct them to contact kidde for a replacement fire extinguisher, free of charge. The recall began on april 11, 2018. Owners may contact dtna customer service at 1-800-547-0712, or contact kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on product safety recall for more information. Dtna's number for this recall is fl-759.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #27 - EXTERIOR LIGHTING:BRAKE LIGHTS
Posted on: 2017-11-30
Description
Daimler trucks north america, llc (dtna) is recalling certain 2008-2018 freightliner cascadia, western star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.
Consequence
If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.
Corrective Action
Dtna will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on january 22, 2018. The recall began on may 9, 2018. Owners may contact dtna customer service at 1-800-547-0712. Dtna's number for this recall is fl-756.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #28 - EXTERIOR LIGHTING:BRAKE LIGHTS:SWITCH
Posted on: 2017-11-30
Description
Daimler trucks north america, llc (dtna) is recalling certain 2008-2018 freightliner cascadia, western star 4700, 4900, 5700, and 6900 trucks. After hard brake applications, the brake light pressure switch may not activate the brake lights with a light application of the brake pedal.
Consequence
If the brake lights fail to illuminate, there would not be a signal to other motorists that the vehicle is slowing, increasing the risk of a crash.
Corrective Action
Dtna will notify owners, and dealers will repair the vehicles, free of charge. Daimler issued interim notifications to owners on january 22, 2018. The recall began on may 9, 2018. Owners may contact dtna customer service at 1-800-547-0712. Dtna's number for this recall is fl-756.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #29 - EXTERIOR LIGHTING
Posted on: 2020-04-15
Description
Daimler trucks north america llc (dtna) is recalling certain 2006-2020 freightliner columbia, 2006-2021 freightliner business class m2, 2007-2020 freightliner coronado, 2014-2021 freightliner 122 sd, 2007 sterling a 9500, 2006 freightliner argosy, 2006-2007 sterling at9500, 2008-2021 freightliner cascadia, 2006-2008 freightliner classic, 2006-2011 freightliner century class, 2006-2010 freightliner fld, and 2017 western star 5700 vehicles. The rear reflective tape may be partially covered by the mudflap hanger bracket, which may reduce the vehicle's visibility to other drivers on the road. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) number 108, lamps, reflective devices, and associated equipment.
Consequence
The vehicle's rearward visibility may be reduced, increasing the risk of a crash.
Corrective Action
Dtna will notify owners, and dealers will inspect and reposition the reflective tape to ensure that it is completely visible, as necessary, free of charge. The recall began may 29, 2020. Owners may contact dtna customer service at 1-800-547-0712. Dtna's number for this recall is fl848.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.