2 recalls found. |
DEFECT #1 - VISIBILITY:WINDSHIELD
Posted on: 2009-01-30
Description
Piaggio is recalling 458 my 2008-2009 aprilia scarabeo 200 motorcycles. These motorcycles fail to comply with the requirements of federal motor vehicle safety standard no. 205 glazing materials. The incorrect dot standard equipment handlebar mounted windshield that was provided was installed. Both dot and euro specifications were sent for installation.
Consequence
This does not meet the requirements of the standard.
Corrective Action
Dealers will replace the windshield component according to dot specifications free of charge. The recall began on june 19, 2009. Owners may contact piaggio at1-212-380-4418.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #2 - FUEL SYSTEM, GASOLINE:CARBURETOR SYSTEM
Posted on: 2009-01-30
Description
Piaggio is recalling 1,260 my 2008-2009 aprilia scarabeo 200 motorcycles. The float level in the float bowl of the carburetor was not set correctly in production, dirt and the varnish residue of dried gasoline not allowing the float needle to seat correctly, and a blockage of the evaporative emission hoses that did not allow the float bowl to vent correctly. The carburetor was not able to maintain correct or constant pressure in the float bowl. Inconsistent pressure in the float bowl would either push too much or not enough fuel to and through the jets for any one throttle position which does not allow the carburetor to correctly meter fuel to the engine.
Consequence
Fuel flooding the engine, causing difficult in starting and poor performance. It is also possible for fuel to leak from the carburetor onto the ground. Fuel leakage, in the presence of an ignition source, could result in a fire.
Corrective Action
Dealers will re-connect the hoses to eliminate the connection of the emissions system to the carburetor. This remedy is free of charge. The recall is expected to begin during february 2009. Owners may contact piaggio at 1-212-380-4431.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .