5 recalls found. |
DEFECT #1 - ELECTRICAL SYSTEM
Posted on: 2011-04-04
Description
Mack trucks is recalling certain model year 2008-2012 mru and leu heavy trucks manufactured from january 3, 2007, through february 3, 2011. The electrical circuitry in these vehicles may not provide adequate overcurrent protection.
Consequence
In the event of an electrical overage, the fuse that should prevent the over current from reaching the mirror switch circuit may fail, such that the mirror switch can overheat. An overheated switch could cause a vehicle fire.
Corrective Action
Dealers will install a relay harness to prevent the mirror switch from overheating. They will also inspect the mirror switch and if signs of overheating are shown, replace that switch. All inspections and repairs will be performed free of charge. The safety recall began on june 30, 2011. Owners may contact mack trucks at 1-800-866-1177.
Notes
Mack trucks safety recall no. Sc0349/sc0350.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #2 - SERVICE BRAKES, AIR
Posted on: 2010-09-13
Description
Mack is recalling certain model year 2008 through 2011 gu and mru model vehicles manufactured with a front tow glad hand option. The actuation and release timing of the vehicles exceeds the limit which fails to conform to the requirements of federal motor vehicle safety standard no. 121, air brake systems.
Consequence
If the brakes do not perform as they should, a vehicle crash could occur.
Corrective Action
Mack will notify owners and repair the vehicle free of charge. The safety recall began on february 1, 2011. Owners may contact mack at 1-877-800-4945.
Notes
Mack's recall campaign number is sc0345.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #3 - STEERING:GEAR BOX:SHAFT SECTOR
Posted on: 2011-07-25
Description
Mack trucks is recalling certain model year 2009-2012 mru heavy trucks manufactured from november 26, 2008, through april 26, 2011. The bolts used to mount the steering gear were not tightened to specification. The bolts can loosen which over time may cause the steering gear to disconnect from its mounting bracket.
Consequence
A complete loss of steering may occur increasing the risk of a vehicle crash.
Corrective Action
Dealers will replace the bolts, which will be tightened to the correct specification. This service will be performed free of charge. The safety recall began on september 19, 2011. Owners may contact mack trucks at 1-800-866-1177.
Notes
Mack trucks recall campaign number is sc0356.owners may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov .
DEFECT #4 - SUSPENSION:FRONT
Posted on: 2012-02-22
Description
Mack is recalling certain model year 2009-2011 mru and model year 2010-2011 leu vehicles, manufactured from january 1, 2009, through september 30, 2010 because the front axle may crack and fracture.
Consequence
Complete fractures can cause the driver to lose control of the vehicle, increasing the risk of a crash.
Corrective Action
Mack will notify owners, and replace the axle beams on affected vehicles when sufficient quantities are available. As an interim measure, a mag particle inspection will be provided to mitigate risk and identify vehicles with cracked axle beams. This service will be performed free of charge. The safety recall began march 30, 2012. Owners may contact mack trucks at 1-800-866-1177.
Notes
Mack¿s recall number is sc0362.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.
DEFECT #5 - EXTERIOR LIGHTING:TURN SIGNAL:FLASHER UNIT
Posted on: 2014-04-23
Description
Mack trucks inc. (mack) is recalling certain model year 2010-2014 chu, cxu, and mru, 2007 ct and cv, 2008-2014 gu, and 2011-2014 leu, and td trucks manufactured february 28, 2006, through november 8, 2013, and equipped hamsar electronic flasher. The hazard warning lights may fail.
Consequence
A failure of the hazard warning lights could reduce the trucks visibility, increasing the risk of a crash.
Corrective Action
Mack will notify owners, and dealers will replace the electronic flasher unit, free of charge. The recall will begin by mid-june 2014. Interim letters went out to owners on june 23, 2014. The recall began on july 25, 2014. Owners may contact mack customer service at 1-866-298-6586. Mack's number for this recall is sc0379.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.