9 recalls found. |
DEFECT #1 - ENGINE AND ENGINE COOLING:ENGINE
Posted on: 2014-03-04
Description
Gillig llc is recalling certain model year 2010-2014 lowfloor transit buses manufactured august 26, 2010, through february 14, 2014, and equipped with certain cummins westport model isl g engines. Condensation in the intake manifold may freeze during cold weather conditions and interfere with the proper operation of the intake manifold pressure sensor.
Consequence
The improper operation of the sensor could induce elevated exhaust temperatures or flames from the exhaust pipe, increasing the risk of a vehicle fire.
Corrective Action
Cummins inc. And cummins wesport inc. Will notify owners, and dealers will upload a new ecm calibration, free of charge. The recall began on march 20, 2014. Owners may contact gillig llc at 1-510-785-1500 or cummins inc. At 1-800-343-7357.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #2 - ELECTRICAL SYSTEM:WIRING
Posted on: 2014-04-29
Description
Gillig llc (gillig) is recalling certain model year 2012-2014 lowfloor transit buses manufactured october 15, 2012, through march 26, 2014, and equipped with electrical harnesses with overmolded j1939 connectors and non-insulated drain wires. The harnesses do not have heat shrink tubing on the drain wire and the overmold may not have sufficient resistance to water or corrosive chemical entry to the connectors.
Consequence
If the terminals corrode, there may be an intermittent electrical connection and possibly cause disruption or loss of the j1939 communication, resulting in interruptions of the engine, transmission, abs and body controllers, increasing the risk of a crash.
Corrective Action
Gillig will notify owners, and dealers will replace the overmold connector, and install heat shrink tubing on the connector/cable junction, free of charge. The recall began in june 2014. Owners may contact gillig customer service at 1-800-735-1500.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #3 - ENGINE AND ENGINE COOLING:ENGINE
Posted on: 2014-06-24
Description
Gillig, llc (gillig) is recalling certain model year 2007-2014 lowfloor transit buses manufactured september 26, 2007, through january 24, 2014. In the affected vehicles, the engine oil sampling hose may leak oil due to being routed too closely to hot engine exhaust components.
Consequence
If the sampling hose leaks oil in the presence of hot engine engine exhaust components, there is an increased risk of fire.
Corrective Action
Gillig will notify owners, and dealers will inspect the oil sampling hose. If the hose is routed too closely, the hose will be removed, replaced and rerouted to provide appropriate clearance of the hot components. The recall is expected to begin in early august 2014. Owners may contact gillig customer service at 1-800-735-1500.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #4 - EXTERIOR LIGHTING:BRAKE LIGHTS
Posted on: 2016-06-21
Description
Gillig llc (gillig) is recalling certain model year 2012-2016 lowfloor diesel-electric hybrid vehicles manufactured march 6, 2012, to june 7, 2016. The affected vehicles are equipped with stop lamp activation that may inadvertently flash the rear brake lights. As such, these vehicles do not comply with the requirements of federal motor vehicle safety standard (fmvss) no. 108, lamps, reflective devices, and assoc. Equipment.
Consequence
Flashing brake lights may cause confusion to other drivers, increasing the risk of a crash.
Corrective Action
Gillig will notify owners, and dealers will install a new software update, free of charge. The recall began on july 2016. Owners may contact gillig customer service at 1-800-735-1500.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #5 - ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
Posted on: 2015-07-01
Description
Gillig llc (gillig) is recalling certain model year 2010-2015 low floor transit buses manufactured april 13, 2010, to june 12, 2015. Due to the routing of the grid heater electrical power cable, the cable may chafe against a fuel injector hard line.
Consequence
If the electrical power cable rubs against the injector fuel line, the cable may short circuit or the fuel line may leak fuel. Either possibility increases the risk of a fire.
Corrective Action
Gillig will notify owners, and dealers will inspect the grid heater power cable/hard injector fuel line for wear, and will properly route and support the grid heater power cable, free of charge. The recall began on july 17, 2015. Owners may contact gillig customer service at 1-800-735-1500.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #6 - ENGINE AND ENGINE COOLING:ENGINE
Posted on: 2015-05-05
Description
Gillig llc (gillig) is recalling certain model year 2010-2015 lowfloor vehicles manufactured august 26, 2010, to april 30, 2015. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.
Consequence
If engine oil comes into contact with a hot surface, there is an increased risk of a fire.
Corrective Action
Gillig will notify owners, and dealers will secure the ends of the 90-degree elbow. In addition, the electronic control module (ecm) will be reprogrammed with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall began on june 2, 2015. Owners may contact gillig customer service at 1-800-735-1500.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #7 - SEATS
Posted on: 2016-01-13
Description
Gillig llc (gillig) is recalling certain model year 2010-2015 low floor transit buses manufactured april 1, 2010 to october 30, 2015, equipped with recaro ergo-m commercial bus driver seats. The affected seats have j-brackets that may be missing welds which could allow the seat belt anchorage assembly to separate from the j-bracket.
Consequence
If the seatbelt anchorage assembly separates from the j-bracket, the bus driver may not be properly restrained in the event of a crash increasing their risk of injury.
Corrective Action
Gillig will notify the owners, and dealers will inspect the seats to determine if welds are missing. Any j-bracket that is missing welds will be removed and replaced, free of charge. The recall began on march 1, 2016. Owners may contact gillig customer service at 1-800-735-1500.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #8 - ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
Posted on: 2020-03-25
Description
Gillig llc (gillig) is recalling certain 2012-2020 low floor buses. The circuit breaker ratings on the def line heater circuit and the aftertreatment-ignition circuit may be higher than the rating for the wire and connector.
Consequence
With the improper circuit breaker rating, an electrical short in either of these circuits may increase the risk of a fire.
Corrective Action
Gillig will notify owners, and dealers will replace the circuit breakers, free of charge. The recall began april 24, 2020. Owners may contact gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #9 - EXTERIOR LIGHTING:TURN SIGNAL
Posted on: 2017-02-28
Description
Gillig llc (gillig) is recalling certain model year 1997-2017 low floor transit buses. The front turn signals installed on standard profile (non-brt) buses may not be sufficiently visible to other drivers or pedestrians. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 108, lamps, reflective devices, and associated equipment.
Consequence
The reduced visibility of the turn signals may increase the risk of a crash.
Corrective Action
Gillig will notify owners, and dealers will install turn signals that have increased visibility. The recall began june 7, 2019. Owners may contact gillig customer service at 1-510-264-5073 or 1-800-735-1500.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.