11 recalls found. |
DEFECT #1 - VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR
Posted on: 2015-05-08
Description
Paccar incorporated (paccar) is recalling certain model year 2011-2016 kenworth t270, t370, t440, t470, c500, c540, c550, t660, t800, w900, and 963 trucks manufactured november 1, 2010, to april 6, 2015. In the affected trucks, water may leak into the wiper motor.
Consequence
As water leaks in, the wiper may cease to function on the 'intermittent' setting, reducing the driver's visibility and increasing the risk of a crash. Additionally, the water may cause corrosion which, over time, may result in an electrical short, increasing the risk of a fire.
Corrective Action
Paccar is still developing and testing a remedy. The recall is expected to begin in july 2015. An interim letter was sent to owners on july 2, 2015. The recall began on september 2, 1015. Owners may contact kenworth customer service at 1-425-828-5000. Paccar's number for this recall is 15kwf.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #2 - ENGINE AND ENGINE COOLING:ENGINE
Posted on: 2015-05-26
Description
Paccar incorporated (paccar) is recalling certain model year 2010-2016 kenworth t440, t800, and w900 trucks manufactured august 31, 2009, to april 20, 2015, and 2008-2015 peterbilt 320, 337, 348, 365, 382, and 384 trucks manufactured july 27, 2007, to april 28, 2015, and equipped with certain cummins westport isl g engines. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.
Consequence
If engine oil comes into contact with a hot surface, there is an increased risk of a fire.
Corrective Action
Cummins will notify owners on behalf of paccar, and cummins service centers will administer the repairs which include securing the ends of the 90-degree elbow and reprogramming the electronic control module (ecm) with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall began on june 12, 2015. Owners may contact kenworth customer service at 1-425-828-5000, peterbilt customer service at 1-940-591-4000 or cummins inc. At 1-800-343-7357. Paccar's number for this recall is 15kwh and 515-g.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #3 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 2015-07-22
Description
Paccar incorporated (paccar) is recalling certain model year 2011-2016 kenworth t440, t470, t660, t680, and t880 trucks manufactured january 14, 2010, to may 22, 2015, and equipped with hid headlamps and the option for daytime running lamps (drl). The drls are required to deactivate when the hazard warning lights are activated, however, the drls on these vehicles override the hazard flashing functionality after the brake pedal is pushed for more than two seconds. Normal hazard flashing functionality returns once the service brake is released. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) no. 108, lamps, reflective devices, and associated equipment.
Consequence
If the hazard warning lamps are overridden by the drl, oncoming vehicles may fail to be warned, increasing the risk of a crash.
Corrective Action
Kenworth will notify owners, and dealers will update the cab controller software, free of charge. The recall began on september 167, 2015. Owners may contact kenworth customer service at 1-425-828-5000. Kenworth's number for this recall is 15kwl.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #4 - EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS
Posted on: 2015-07-22
Description
Paccar incorporated (paccar) is recalling certain model year 2011-2016 kenworth t440, t470, t660, t680, and t880 trucks manufactured january 14, 2010, to may 22, 2015, and equipped with hid headlamps and the option for daytime running lamps (drl). The drls are required to deactivate when the hazard warning lights are activated, however, the drls on these vehicles override the hazard flashing functionality after the brake pedal is pushed for more than two seconds. Normal hazard flashing functionality returns once the service brake is released. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) no. 108, lamps, reflective devices, and associated equipment.
Consequence
If the hazard warning lamps are overridden by the drl, oncoming vehicles may fail to be warned, increasing the risk of a crash.
Corrective Action
Kenworth will notify owners, and dealers will update the cab controller software, free of charge. The recall began on september 167, 2015. Owners may contact kenworth customer service at 1-425-828-5000. Kenworth's number for this recall is 15kwl.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #5 - SERVICE BRAKES, AIR
Posted on: 2015-07-22
Description
Paccar incorporated (paccar) is recalling certain model year 2016 kenworth t440, t470, t660, t680, t800, t880, and w900 trucks manufactured february 16, 2015, to march 9, 2015. The affected vehicles are equipped with an sr-7 spring brake valve assembly that may have had the primary and secondary service brake applications installed in reverse. In the event of a failure in the primary or secondary circuit, the redundant circuit would not provide adequate service brake functionality. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard (fmvss) no. 121, air brake systems.
Consequence
A loss of braking ability would increase the risk of a crash.
Corrective Action
Kenworth will notify owners, and dealers will inspect the vehicles and correct the air line installations as required, free of charge. The recall began on september 16, 2015. Owners may contact kenworth customer service at 1-425-828-5000. Paccar's number for this recall is 15kwk.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #6 - STEERING
Posted on: 2017-09-26
Description
Paccar incorporated (paccar) is recalling certain 2016 peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389g, 567, 579 and 587 trucks and kenworth k170, t170, t270, t370, t440, t470,t660, t680, t800, t880, and w900 trucks equipped with certain spicer d or e series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence
If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on november 13, 2017. Owners may contact peterbilt customer service at 1-940-591-4000 or kenworth customer service at 1-425-828-5000. Paccar's number for this recall is p817-c.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #7 - STEERING:LINKAGES:TIE ROD ASSEMBLY
Posted on: 2017-09-26
Description
Paccar incorporated (paccar) is recalling certain 2016 peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389g, 567, 579 and 587 trucks and kenworth k170, t170, t270, t370, t440, t470,t660, t680, t800, t880, and w900 trucks equipped with certain spicer d or e series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence
If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on november 13, 2017. Owners may contact peterbilt customer service at 1-940-591-4000 or kenworth customer service at 1-425-828-5000. Paccar's number for this recall is p817-c.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #8 - STEERING
Posted on: 2017-09-26
Description
Paccar incorporated (paccar) is recalling certain 2016 peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389g, 567, 579 and 587 trucks and kenworth k170, t170, t270, t370, t440, t470,t660, t680, t800, t880, and w900 trucks equipped with certain spicer d or e series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence
If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on november 13, 2017. Owners may contact peterbilt customer service at 1-940-591-4000 or kenworth customer service at 1-425-828-5000. Paccar's number for this recall is p817-c.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #9 - STEERING:LINKAGES:TIE ROD ASSEMBLY
Posted on: 2017-09-26
Description
Paccar incorporated (paccar) is recalling certain 2016 peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389g, 567, 579 and 587 trucks and kenworth k170, t170, t270, t370, t440, t470,t660, t680, t800, t880, and w900 trucks equipped with certain spicer d or e series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence
If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on november 13, 2017. Owners may contact peterbilt customer service at 1-940-591-4000 or kenworth customer service at 1-425-828-5000. Paccar's number for this recall is p817-c.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #10 - STEERING
Posted on: 2017-09-26
Description
Paccar incorporated (paccar) is recalling certain 2016 peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389g, 567, 579 and 587 trucks and kenworth k170, t170, t270, t370, t440, t470,t660, t680, t800, t880, and w900 trucks equipped with certain spicer d or e series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence
If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on november 13, 2017. Owners may contact peterbilt customer service at 1-940-591-4000 or kenworth customer service at 1-425-828-5000. Paccar's number for this recall is p817-c.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #11 - STEERING:LINKAGES:TIE ROD ASSEMBLY
Posted on: 2017-09-26
Description
Paccar incorporated (paccar) is recalling certain 2016 peterbilt 220, 320, 325, 330, 337, 348, 365, 367, 382, 384, 386, 389, 389g, 567, 579 and 587 trucks and kenworth k170, t170, t270, t370, t440, t470,t660, t680, t800, t880, and w900 trucks equipped with certain spicer d or e series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence
If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering and increasing the risk of a crash.
Corrective Action
Paccar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on november 13, 2017. Owners may contact peterbilt customer service at 1-940-591-4000 or kenworth customer service at 1-425-828-5000. Paccar's number for this recall is p817-c.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.