14 recalls found. |
DEFECT #1 - ELECTRICAL SYSTEM:WIRING
Posted on: 2017-03-17
Description
Volvo bus corporation (volvo bus) is recalling certain 2016-2017 volvo 9700 transit buses equipped with the i-start feature. These vehicles have a ground cable that may have been improperly installed, resulting in inadequate electrical contact. The poor contact may cause the power feed relay to fail and the engine to stall.
Consequence
An unexpected engine shutdown increases the risk of a crash.
Corrective Action
Volvo bus will notify owners, and dealers will inspect the vehicles and correct the ground wire installation, as necessary, free of charge. The recall began on may 4, 2017. Owners may contact volvo bus customer service 1-877-773-8678. Volvo bus' number for this recall is sr17-80. Note: the affected vehicles were previously remedied for a similar issue under recall 16v836, however, this recall requires additional repairs to ensure that the power feed relay will not fail.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #2 - ELECTRICAL SYSTEM:WIRING
Posted on: 2017-12-29
Description
Volvo bus corporation (volvo) is recalling certain 2016-2018 9700 buses equipped with i-start. The hardware that attaches the power supply cable to the fuse box may not be properly tightened, possibly causing the power cable and fuse box to overheat.
Consequence
The power cable and fuse box can overheat, increasing the risk of a fire.
Corrective Action
Volvo will notify owners, and dealers will inspect the fuse box for damage, and replace it if necessary, as well as replace and tighten the nuts attaching the power cable, free of charge. The recall began february 2, 2018. Owners may contact volvo customer service at 1-866-870-2046. Volvo's number for this recall is sr17-85.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #3 - ELECTRICAL SYSTEM:WIRING
Posted on: 2017-12-29
Description
Volvo bus corporation (volvo) is recalling certain 2016-2018 9700 buses equipped with i-start. The hardware that attaches the power supply cable to the fuse box may not be properly tightened, possibly causing the power cable and fuse box to overheat.
Consequence
The power cable and fuse box can overheat, increasing the risk of a fire.
Corrective Action
Volvo will notify owners, and dealers will inspect the fuse box for damage, and replace it if necessary, as well as replace and tighten the nuts attaching the power cable, free of charge. The recall began february 2, 2018. Owners may contact volvo customer service at 1-866-870-2046. Volvo's number for this recall is sr17-85.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #4 - POWER TRAIN:AUTOMATIC TRANSMISSION
Posted on: 2020-12-22
Description
Volvo bus corporation (volvo bus) is recalling certain 2015-2020 9700 buses. The transmission c1 hub may fail which may lead to a disabled vehicle.
Consequence
A disabled bus may require passengers to transfer to a different bus on the side of the road, increasing the risk of injury.
Corrective Action
Volvo bus will notify owners, and dealers will update the transmission control module (tcm) calibration software, free of charge. The recall is expected to begin february 12, 2021. Owners may contact volvo bus customer service at 1-866-870-2046.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.
DEFECT #5 - EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR LIFT/RAMP
Posted on: 2021-08-03
Description
Volvo bus corporation (volvo bus) is recalling certain 2009-2021 volvo 9700 vehicles equipped with wheelchair lifts. When the lift's outer barrier is fully deployed, it may not withstand a sufficient amount of force, which could cause it to fail. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard numbers 403, platform lift systems and 404, platform lift installations.
Consequence
In the event that a mobility device pushes into the outer barrier, the barrier may fail, increasing the risk of injury for the lift occupant.
Corrective Action
Volvo bus will reinforce the outer barrier with additional supports, free of charge. Owner notification letters are expected to be mailed september 24, 2021. Owners may contact volvo bus customer service at 1-866-870-2046.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.nhtsa.gov.
DEFECT #6 - EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR LIFT/RAMP
Posted on: 2021-08-03
Description
Volvo bus corporation (volvo bus) is recalling certain 2009-2021 volvo 9700 vehicles equipped with wheelchair lifts. When the lift's outer barrier is fully deployed, it may not withstand a sufficient amount of force, which could cause it to fail. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard numbers 403, platform lift systems and 404, platform lift installations.
Consequence
In the event that a mobility device pushes into the outer barrier, the barrier may fail, increasing the risk of injury for the lift occupant.
Corrective Action
Volvo bus will reinforce the outer barrier with additional supports, free of charge. Interim owner notification letters were mailed on september 28, 2021. Owner notification letters were mailed on march 18, 2022. Owners may contact volvo bus customer service at 1-866-870-2046.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.nhtsa.gov.
DEFECT #7 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 2021-09-16
Description
Volvo bus corporation (volvo bus) is recalling certain 2008-2021 9700 vehicles. The headlights may not have the correct amount of light output, and either be too bright, or too dim. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 108, lamps, reflective devices, and associated equipment.
Consequence
Excessively bright or dim headlights may reduce visibility, increasing the risk of a crash.
Corrective Action
Dealers will replace of the headlight assembly or the bulbs, free of charge. Estimated start date for repairing vehicles is by march 31, 2022. Owners were notified of the safety risk on november 11, 2021. A second letter will be sent once the remedy is available. Owners may contact volvo bus' customer service at 1-866-870-2046.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.nhtsa.gov.
DEFECT #8 - EXTERIOR LIGHTING:HEADLIGHTS:BULBS
Posted on: 2021-09-16
Description
Volvo bus corporation (volvo bus) is recalling certain 2008-2021 9700 vehicles. The headlights may not have the correct amount of light output, and either be too bright, or too dim. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 108, lamps, reflective devices, and associated equipment.
Consequence
Excessively bright or dim headlights may reduce visibility, increasing the risk of a crash.
Corrective Action
Dealers will replace of the headlight assembly or the bulbs, free of charge. Estimated start date for repairing vehicles is by march 31, 2022. Owners were notified of the safety risk on november 11, 2021. A second letter will be sent once the remedy is available. Owners may contact volvo bus' customer service at 1-866-870-2046.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.nhtsa.gov.
DEFECT #9 - EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR LIFT/RAMP
Posted on: 2021-08-03
Description
Volvo bus corporation (volvo bus) is recalling certain 2009-2021 volvo 9700 vehicles equipped with wheelchair lifts. When the lift's outer barrier is fully deployed, it may not withstand a sufficient amount of force, which could cause it to fail. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard numbers 403, platform lift systems and 404, platform lift installations.
Consequence
In the event that a mobility device pushes into the outer barrier, the barrier may fail, increasing the risk of injury for the lift occupant.
Corrective Action
Volvo bus will reinforce the outer barrier with additional supports, free of charge. Interim owner notification letters were mailed on september 28, 2021. Owner notification letters were mailed on march 18, 2022. Owners may contact volvo bus customer service at 1-866-870-2046.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.nhtsa.gov.
DEFECT #10 - EXTERIOR LIGHTING:HEADLIGHTS
Posted on: 2021-09-16
Description
Volvo bus corporation (volvo bus) is recalling certain 2008-2021 9700 vehicles. The headlights may not have the correct amount of light output, and either be too bright, or too dim. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 108, lamps, reflective devices, and associated equipment.
Consequence
Excessively bright or dim headlights may reduce visibility, increasing the risk of a crash.
Corrective Action
Dealers will replace of the headlight assembly or the bulbs, free of charge. Estimated start date for repairing vehicles is by march 31, 2022. Owners were notified of the safety risk on november 11, 2021. A second letter will be sent once the remedy is available. Owners may contact volvo bus' customer service at 1-866-870-2046.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.nhtsa.gov.
DEFECT #11 - EXTERIOR LIGHTING:HEADLIGHTS:BULBS
Posted on: 2021-09-16
Description
Volvo bus corporation (volvo bus) is recalling certain 2008-2021 9700 vehicles. The headlights may not have the correct amount of light output, and either be too bright, or too dim. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 108, lamps, reflective devices, and associated equipment.
Consequence
Excessively bright or dim headlights may reduce visibility, increasing the risk of a crash.
Corrective Action
Dealers will replace of the headlight assembly or the bulbs, free of charge. Estimated start date for repairing vehicles is by march 31, 2022. Owners were notified of the safety risk on november 11, 2021. A second letter will be sent once the remedy is available. Owners may contact volvo bus' customer service at 1-866-870-2046.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.nhtsa.gov.
DEFECT #12 - EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR LIFT/RAMP
Posted on: 2023-12-26
Description
Volvo bus corporation (volvo bus) is recalling certain 2013-2021 9700 buses. The red beacon lighting on the threshold warning system (tws) may not be bright enough. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 403, platform lift systems.
Consequence
Beacons that do not provide proper illumination may be less visible to wheelchair lift users, increasing the risk of injury.
Corrective Action
Prevost will replace the red beacons, free of charge. Interim letters notifying owners of the safety risk were mailed february 7, 2024. A second notice will be mailed once the remedy is available. Owners may contact volvo bus customer service at 1-866-870-2043. Volvo bus number for this recall is sr24-81.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.nhtsa.gov.
DEFECT #13 - EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR LIFT/RAMP
Posted on: 2023-12-26
Description
Volvo bus corporation (volvo bus) is recalling certain 2013-2021 9700 buses. The red beacon lighting on the threshold warning system (tws) may not be bright enough. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 403, platform lift systems.
Consequence
Beacons that do not provide proper illumination may be less visible to wheelchair lift users, increasing the risk of injury.
Corrective Action
Prevost will replace the red beacons, free of charge. Interim letters notifying owners of the safety risk were mailed february 7, 2024. A second notice will be mailed once the remedy is available. Owners may contact volvo bus customer service at 1-866-870-2043. Volvo bus number for this recall is sr24-81.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.nhtsa.gov.
DEFECT #14 - EQUIPMENT ADAPTIVE/MOBILITY:WHEELCHAIR LIFT/RAMP
Posted on: 2023-12-26
Description
Volvo bus corporation (volvo bus) is recalling certain 2013-2021 9700 buses. The red beacon lighting on the threshold warning system (tws) may not be bright enough. As such, these vehicles fail to comply with the requirements of federal motor vehicle safety standard number 403, platform lift systems.
Consequence
Beacons that do not provide proper illumination may be less visible to wheelchair lift users, increasing the risk of injury.
Corrective Action
Prevost will replace the red beacons, free of charge. Interim letters notifying owners of the safety risk were mailed february 7, 2024. A second notice will be mailed once the remedy is available. Owners may contact volvo bus customer service at 1-866-870-2043. Volvo bus number for this recall is sr24-81.
Notes
Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.nhtsa.gov.