2019 Nova Bus Lfs Artic Recall Information and Defects

Defect #1: Hose, Piping, And Connections Malfunction (MFR Campaign: CR4963)

Description

Nova Bus (Nova) is recalling certain 2020 Nova Bus LFS transit buses. Certain power steering pipes from the rear engine bay to the front gear box may separate at the connection joint. This may cause a power steering assist lost and power steering fluid may leak from the ceiling into the passenger compartment.

Consequence

A loss of power steering assist may increase the risk of a crash. A power steering fluid leak into the passenger cabin may increase the risk of a passenger injury.

Corrective Action

Nova Bus will notify owners, provide instructions for inspecting and replacing the power steering pipes, free of charge. The recall began October 7, 2020. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR4963

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www. safercar.gov

Defect #2: Fuel Rail Malfunction (MFR Campaign: CR5120E)

Description

Nova Bus is recalling certain 2016-2020 LFS and LFS Artic vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.

Consequence

A fuel leak in the presence of an ignition source increases the risk of a fire.

Corrective Action

Dealers will inspect the rail threads, and replace the rail as necessary, free of charge. Owner notification letters were mailed on July 9, 2021. Owners may contact Nova Bus customer service at 1-800-350-6682

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www. safercar.gov

Defect #3: Fan Malfunction (MFR Campaign: CR5259)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2021 LFS and 2019-2022 LFS Artic buses. The radiator fan's electrical fuse holder may experience excessive corrosion which can result in an electrical short.

Consequence

An electrical short increases the risk of a fire.

Corrective Action

Nova Bus will provide the remedy parts and service document instructions, free of charge. Owner notification letters were mailed on June 29, 2022. Owners may contact Nova Bus' customer service at 1-800-350-6682. Nova Bus' number for this recall is CR5259

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #4: Fuses And Circuit Breakers Malfunction (MFR Campaign: CR5259)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2021 LFS and 2019-2022 LFS Artic buses. The radiator fan's electrical fuse holder may experience excessive corrosion which can result in an electrical short.

Consequence

An electrical short increases the risk of a fire.

Corrective Action

Nova Bus will provide the remedy parts and service document instructions, free of charge. Owner notification letters were mailed on June 29, 2022. Owners may contact Nova Bus' customer service at 1-800-350-6682. Nova Bus' number for this recall is CR5259

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #5: Exterior Lighting Malfunction (MFR Campaign: CR5267/68/69)

Description

Nova Bus (US) Inc. (Nova) is recalling certain 2016-2020 LFS and 2013-2022 LFS Artic buses. The momentary STOP and YIELD text message board is duplicating the stop light and turn signal light signals. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence

The momentary text message board duplicating light signals may cause confusion, increasing the risk of a crash.

Corrective Action

Nova will coordinate with Prevost Service Centers to remove the momentary text message board duplicating light signals and associated equipment, free of charge. Owner notification letters were mailed on June 27, 2022. Owners may contact Nova's customer service at 1-800-350-6682. Nova's number for this recall is CR5267/68/69

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #6: Exterior Lighting Malfunction (MFR Campaign: CR5267/68/69)

Description

Nova Bus (US) Inc. (Nova) is recalling certain 2016-2020 LFS and 2013-2022 LFS Artic buses. The momentary STOP and YIELD text message board is duplicating the stop light and turn signal light signals. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence

The momentary text message board duplicating light signals may cause confusion, increasing the risk of a crash.

Corrective Action

Nova will coordinate with Prevost Service Centers to remove the momentary text message board duplicating light signals and associated equipment, free of charge. Owner notification letters were mailed on June 27, 2022. Owners may contact Nova's customer service at 1-800-350-6682. Nova's number for this recall is CR5267/68/69

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #7: Exterior Lighting Malfunction (MFR Campaign: CR5267/68/69)

Description

Nova Bus (US) Inc. (Nova) is recalling certain 2016-2020 LFS and 2013-2022 LFS Artic buses. The momentary STOP and YIELD text message board is duplicating the stop light and turn signal light signals. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence

The momentary text message board duplicating light signals may cause confusion, increasing the risk of a crash.

Corrective Action

Nova will coordinate with Prevost Service Centers to remove the momentary text message board duplicating light signals and associated equipment, free of charge. Owner notification letters were mailed on June 27, 2022. Owners may contact Nova's customer service at 1-800-350-6682. Nova's number for this recall is CR5267/68/69

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #8: Equipment Malfunction (MFR Campaign: CR5267/68/69)

Description

Nova Bus (US) Inc. (Nova) is recalling certain 2016-2020 LFS and 2013-2022 LFS Artic buses. The momentary STOP and YIELD text message board is duplicating the stop light and turn signal light signals. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence

The momentary text message board duplicating light signals may cause confusion, increasing the risk of a crash.

Corrective Action

Nova will coordinate with Prevost Service Centers to remove the momentary text message board duplicating light signals and associated equipment, free of charge. Owner notification letters were mailed on June 27, 2022. Owners may contact Nova's customer service at 1-800-350-6682. Nova's number for this recall is CR5267/68/69

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #9: Equipment Malfunction (MFR Campaign: CR5267/68/69)

Description

Nova Bus (US) Inc. (Nova) is recalling certain 2016-2020 LFS and 2013-2022 LFS Artic buses. The momentary STOP and YIELD text message board is duplicating the stop light and turn signal light signals. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence

The momentary text message board duplicating light signals may cause confusion, increasing the risk of a crash.

Corrective Action

Nova will coordinate with Prevost Service Centers to remove the momentary text message board duplicating light signals and associated equipment, free of charge. Owner notification letters were mailed on June 27, 2022. Owners may contact Nova's customer service at 1-800-350-6682. Nova's number for this recall is CR5267/68/69

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #10: Equipment Malfunction (MFR Campaign: CR5267/68/69)

Description

Nova Bus (US) Inc. (Nova) is recalling certain 2016-2020 LFS and 2013-2022 LFS Artic buses. The momentary STOP and YIELD text message board is duplicating the stop light and turn signal light signals. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence

The momentary text message board duplicating light signals may cause confusion, increasing the risk of a crash.

Corrective Action

Nova will coordinate with Prevost Service Centers to remove the momentary text message board duplicating light signals and associated equipment, free of charge. Owner notification letters were mailed on June 27, 2022. Owners may contact Nova's customer service at 1-800-350-6682. Nova's number for this recall is CR5267/68/69

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #11: Fuses And Circuit Breakers Malfunction (MFR Campaign: CR5445)

Description

Nova Bus (US) Inc. (Nova) is recalling certain 2017-2023 LFS and 2017-2022 LFS Artic transit buses. The 24-volt power cable and grounded mounting fastener that secures the fuse holder may short circuit.

Consequence

An electrical short circuit can overheat the fuse holder and increase the risk of a fire while driving or parked.

Corrective Action

Nova will insect, remove, and clean the fuse holder and cable lugs as necessary, free of charge. Owner letters were mailed November 7, 2023. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5445. This recall replaces and expands recall number 22V-416. Vehicles previously repaired under recall 22V-416 will need to have the new remedy completed

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #12: Critical Fasteners Malfunction (MFR Campaign: CR5500)

Description

Nova Bus (US) Inc. (Nova) is recalling certain 2015-2019 LFS and LFS Artic transit buses. The attachment hardware may have been incorrectly installed beneath the rear wheel well passenger seats, allowing the seat to detach from the frame.

Consequence

A detached passenger seat may inadequately restrain a passenger during a crash, increasing the risk of injury.

Corrective Action

Owners are advised not to drive their vehicles until the remedy is completed. Nova Bus will inspect and replace the attachment hardware as necessary, free of charge. Owner notification letters were mailed December 1, 2023. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus number for this recall is CR5500

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #13: Critical Fasteners Malfunction (MFR Campaign: CR5342)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2018-2022 LFS and 2018-2021 LFS Artic buses equipped with a Bosch steering gear box. The steering gear box may have an insufficient clamp load, which may allow the mounting plate sub-assembly fasteners to loosen and possibly fall out.

Consequence

Missing fasteners may cause a of a loss of steering, increasing the risk of a crash.

Corrective Action

Owners are advised not to drive their vehicles until the remedy has been completed. Nova Bus will inspect and tighten the fasteners as an interim remedy. The permanent remedy, consisting of replacing and tightening new fasteners to increase the clamp load, is expected to be available November 30, 2022, free of charge. Owner notification letters were mailed November 16, 2022. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5342

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #14: Critical Fasteners Malfunction (MFR Campaign: CR5342)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2018-2022 LFS and 2018-2021 LFS Artic buses equipped with a Bosch steering gear box. The steering gear box may have an insufficient clamp load, which may allow the mounting plate sub-assembly fasteners to loosen and possibly fall out.

Consequence

Missing fasteners may cause a of a loss of steering, increasing the risk of a crash.

Corrective Action

Owners are advised not to drive their vehicles until the remedy has been completed. Nova Bus will inspect and tighten the fasteners as an interim remedy. The permanent remedy, consisting of replacing and tightening new fasteners to increase the clamp load, is expected to be available November 30, 2022, free of charge. Owner notification letters were mailed November 16, 2022. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5342

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #15: Critical Fasteners Malfunction (MFR Campaign: CR5342)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2018-2022 LFS and 2018-2021 LFS Artic buses equipped with a Bosch steering gear box. The steering gear box may have an insufficient clamp load, which may allow the mounting plate sub-assembly fasteners to loosen and possibly fall out.

Consequence

Missing fasteners may cause a of a loss of steering, increasing the risk of a crash.

Corrective Action

Owners are advised not to drive their vehicles until the remedy has been completed. Nova Bus will inspect and tighten the fasteners as an interim remedy. The permanent remedy, consisting of replacing and tightening new fasteners to increase the clamp load, is expected to be available November 30, 2022, free of charge. Owner notification letters were mailed November 16, 2022. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5342

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #16: Critical Fasteners Malfunction (MFR Campaign: CR5342)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2018-2022 LFS and 2018-2021 LFS Artic buses equipped with a Bosch steering gear box. The steering gear box may have an insufficient clamp load, which may allow the mounting plate sub-assembly fasteners to loosen and possibly fall out.

Consequence

Missing fasteners may cause a of a loss of steering, increasing the risk of a crash.

Corrective Action

Owners are advised not to drive their vehicles until the remedy has been completed. Nova Bus will inspect and tighten the fasteners as an interim remedy. The permanent remedy, consisting of replacing and tightening new fasteners to increase the clamp load, is expected to be available November 30, 2022, free of charge. Owner notification letters were mailed November 16, 2022. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5342

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #17: Electrical Heating Element Malfunction (MFR Campaign: CR5637)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2024 LFS and 2019-2023 LFS Artic buses. The auxiliary heater module may allow contaminants to enter the electronic controller, which can cause an electrical short. Additionally, the auxiliary heater may fail, causing the defrosting system to not function properly.

Consequence

An electrical short circuit can increase the risk of a fire. Additionally, a windshield defrosting system that does not function properly can decrease the driver's visibility, increasing the risk of a crash.

Corrective Action

Nova Bus will the auxiliary heater air intake, free of charge. Owner notification letters were mailed January 28, 2025. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5637

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #18: Electrical Heating Element Malfunction (MFR Campaign: CR5637)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2024 LFS and 2019-2023 LFS Artic buses. The auxiliary heater module may allow contaminants to enter the electronic controller, which can cause an electrical short. Additionally, the auxiliary heater may fail, causing the defrosting system to not function properly.

Consequence

An electrical short circuit can increase the risk of a fire. Additionally, a windshield defrosting system that does not function properly can decrease the driver's visibility, increasing the risk of a crash.

Corrective Action

Nova Bus will the auxiliary heater air intake, free of charge. Owner notification letters were mailed January 28, 2025. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5637

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #19: Electrical Malfunction (MFR Campaign: CR5637)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2024 LFS and 2019-2023 LFS Artic buses. The auxiliary heater module may allow contaminants to enter the electronic controller, which can cause an electrical short. Additionally, the auxiliary heater may fail, causing the defrosting system to not function properly.

Consequence

An electrical short circuit can increase the risk of a fire. Additionally, a windshield defrosting system that does not function properly can decrease the driver's visibility, increasing the risk of a crash.

Corrective Action

Nova Bus will the auxiliary heater air intake, free of charge. Owner notification letters were mailed January 28, 2025. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5637

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #20: Electrical Malfunction (MFR Campaign: CR5637)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2024 LFS and 2019-2023 LFS Artic buses. The auxiliary heater module may allow contaminants to enter the electronic controller, which can cause an electrical short. Additionally, the auxiliary heater may fail, causing the defrosting system to not function properly.

Consequence

An electrical short circuit can increase the risk of a fire. Additionally, a windshield defrosting system that does not function properly can decrease the driver's visibility, increasing the risk of a crash.

Corrective Action

Nova Bus will the auxiliary heater air intake, free of charge. Owner notification letters were mailed January 28, 2025. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5637

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #21: Front Malfunction (MFR Campaign: CR5635)

Description

Nova Bus (US) Inc. (Nova) is recalling certain 2010-2020 LFS Artic and 2012-2024 LFS vehicles. The driver's seat belt may not retract properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."

Consequence

A seat belt that does not retract properly may result in a loose seat belt, which can increase the risk of injury in a crash.

Corrective Action

The remedy is currently under development. Interim owner notification letters explaining the safety risk were mailed October 31, 2024. A second notice will be sent once the remedy has been finalized. Nova's number for this recall is CR5635. This recall expands and replaces previous recall number 23V-350. Vehicles that were previously recalled under 23V-350 will need to have the new remedy completed

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #22: Front Malfunction (MFR Campaign: CR5635)

Description

Nova Bus (US) Inc. (Nova) is recalling certain 2010-2020 LFS Artic and 2012-2024 LFS vehicles. The driver's seat belt may not retract properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 209, "Seat Belt Assemblies."

Consequence

A seat belt that does not retract properly may result in a loose seat belt, which can increase the risk of injury in a crash.

Corrective Action

The remedy is currently under development. Interim owner notification letters explaining the safety risk were mailed October 31, 2024. A second notice will be sent once the remedy has been finalized. Nova's number for this recall is CR5635. This recall expands and replaces previous recall number 23V-350. Vehicles that were previously recalled under 23V-350 will need to have the new remedy completed

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #23: Driveshaft Malfunction (MFR Campaign: CR5442)

Description

Nova Bus (US) Inc. (Nova) is recalling certain 2019-2023 LFS and LFS Artic transit buses. The transmission yoke may separate, resulting in driveshaft separation and a sudden loss of drive power.

Consequence

A sudden loss of drive power can increase the risk of a crash. Additionally, a disabled bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.

Corrective Action

Dealers will inspect the output yoke bolts, and if necessary, tighten loose output yoke bolts, free of charge. Phase 1 will include 2019-2023 LFS vehicles. Nova notified dealers on 10/03/2024 and notified Phase 1 owners on 10/27/2024. Phase 2 will include 2019-2020 LFS Artic vehicles. Interim letters informing owners of the safety risk were mailed on October 27, 2023. A second notice will be mailed to Phase 2 owners once the remedy is available, expected in January 2025. Owners may contact Nova customer service at 1-800-350-6682. Nova's number for this recall is CR5442

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #24: Chamber Malfunction (MFR Campaign: CR5620)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2021 LFS and 2019 LFS Artic buses. The brake chamber on the rear axle may have been improperly manufactured, which can result in an air leak.

Consequence

A brake chamber air leak may cause the brakes to engage unexpectedly, which can overheat the brakes and increase the risk of a fire. Additionally, unexpected braking can increase the risk of a crash.

Corrective Action

Nova Bus will inspect and replace the brake chamber as necessary, free of charge. Owner notification letters were mailed November 02, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5620

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #25: Glass, Side/rear Malfunction (MFR Campaign: CR5626)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2023 LFS and 2019-2020 LFS Arctic buses. The glazing used on the glass windows may reduce the driver's visibility. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 205, "Glazing Materials."

Consequence

Reduced visibility while driving can increase the risk of a crash.

Corrective Action

Nova Bus will inspect the vehicles and replace the driver shield glazing as necessary, free of charge. Owner notification letters were mailed October 10, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5626

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #26: Glass, Side/rear Malfunction (MFR Campaign: CR5626)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2019-2023 LFS and 2019-2020 LFS Arctic buses. The glazing used on the glass windows may reduce the driver's visibility. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 205, "Glazing Materials."

Consequence

Reduced visibility while driving can increase the risk of a crash.

Corrective Action

Nova Bus will inspect the vehicles and replace the driver shield glazing as necessary, free of charge. Owner notification letters were mailed October 10, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5626

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #27: Chamber Malfunction (MFR Campaign: CR5619)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2016-2019 LFS and LFS Artic buses. The brake chamber on the rear axle may have been improperly manufactured, which can result in an air leak.

Consequence

A brake chamber air leak may cause the brakes to engage unexpectedly, which can overheat the brakes and increase the risk of a fire. Additionally, unexpected braking can increase the risk of a crash.

Corrective Action

Nova Bus will inspect and replace the brake chamber as necessary, free of charge. Owner notification letters were mailed November 02, 2024. Owners may contact Nova Bus customer service at 1-800-350-6682. Nova Bus's number for this recall is CR5619

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.Nhtsa.Gov

Defect #28: Seats Malfunction (MFR Campaign: CR5858)

Description

Nova Bus (US) Inc. (Nova Bus) is recalling certain 2013-2019 LFS and 2019-2020 LFS Artic transit buses equipped with Double Transversal seats. The passenger seat mounting rails may crack, causing the seat to detach and fall to the floor.

Consequence

A seat that falls unexpectedly increases the risk of injury to passengers in or near to the seat.

Corrective Action

Nova Bus will replace the attachment brackets, free of charge. Owner notification letters are expected to be mailed April 11, 2026. Owners may contact Nova Bus customer service at 1-450-472-6410. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA. Gov beginning April 11, 2026

Notes