2025 Orange Ev Husk-e Recall Information and Defects
The 2025 Orange Ev Husk-e has 7 active safety recalls issued by the NHTSA and Orange EV. These critical defects primarily concern critical fasteners, thermal management, and hazard flashing warning lights. Review the full details below, including NHTSA and Manufacturer Campaign numbers.
Quick Jump to Recalls (7 Defects)
Defect #1: Critical Fasteners Malfunction (MFR Campaign: 2025-SRC-02)
NHTSA ID: 25V360000 | MFR Campaign Number: 2025-SRC-02
Posted on: 2025-05-30
Description
Orange EV is recalling certain 2023-2025 HUSK-e, e-TRIEVER, and 2022-2024 T-Series trucks. The bolts securing the upper steering shaft clamp may have been improperly tightened.
Consequence
The loose bolts can cause steering system components to separate, resulting in loss of steering control and increasing the risk of a crash.
Corrective Action
Orange EV service will replace the upper steering shaft clamp bolts, free of charge. Owner notification letters are scheduled to be mailed July 29, 2025. Owners may contact Orange EV customer service at
1-866-688-5223
Notes
Defect #2: Thermal Management Malfunction (MFR Campaign: 2025-SRC-04)
NHTSA ID: 25V367000 | MFR Campaign Number: 2025-SRC-04
Posted on: 2025-06-02
Description
Orange EV (OEV) is recalling certain 2023-2025 Orange EV Husk-e terminal trucks. The high voltage short circuit protection system may have an inadequate fuse.
Consequence
In the event of a short, the fuse may open too slowly or not at all, increasing the risk of a fire.
Corrective Action
OEV will replace the fuse, free of charge. Owner notification letters are expected to be mailed June 13, 2025. Owners may contact OEV customer service at
1-866-688-5223. OEV's number for this recall is 2025-SRC-04
Notes
Defect #3: Hazard Flashing Warning Lights Malfunction (MFR Campaign: 2025-SRC-07)
NHTSA ID: 25V612000 | MFR Campaign Number: 2025-SRC-07
Posted on: 2025-09-15
Description
Orange EV (OEV) is recalling certain 2017-2024 T-Series, 2023-2025 e-TRIEVER, and HUSK-e terminal trucks. The hazard warning lights may turn off when the ignition is in the 'Off' position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence
Hazard lights that do not remain on cannot warn other drivers of a disabled vehicle, increasing the risk of a crash.
Corrective Action
OEV field service will install a new hazard light wire harness and update the software, free of charge. Owner notification letters are expected to be mailed by October 31, 2025. Owners may contact OEV customer service at
1-866-688-5223. OEV's number for this recall is 2025-SRC-07
Notes
Defect #4: Critical Fasteners Malfunction (MFR Campaign: 2025-SRC-02)
NHTSA ID: 25V360000 | MFR Campaign Number: 2025-SRC-02
Posted on: 2025-05-30
Description
Orange EV is recalling certain 2023-2025 HUSK-e, e-TRIEVER, and 2022-2024 T-Series trucks. The bolts securing the upper steering shaft clamp may have been improperly tightened.
Consequence
The loose bolts can cause steering system components to separate, resulting in loss of steering control and increasing the risk of a crash.
Corrective Action
Orange EV service will replace the upper steering shaft clamp bolts, free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Orange EV customer service at
1-866-688-5223
Notes
Defect #5: Critical Fasteners Malfunction (MFR Campaign: 2025-SRC-05)
NHTSA ID: 25V445000 | MFR Campaign Number: 2025-SRC-05
Posted on: 2025-06-30
Description
Orange EV (OEV) is recalling certain 2023-2025 HUSK-e terminal trucks previously remedied under Recall 25V367 (2025-SRC-04). The wrong size washer was installed in the thermal fuse bolted joint during the previous repair.
Consequence
The incorrect washer can cause the bus bar connection to loosen or open, resulting in electrical arcing and increasing the risk of a fire.
Corrective Action
OEV will install the correctly sized washer, free of charge. Owner notification letters are expected to be mailed July 9, 2025. Owners may contact OEV customer service at
1-866-688-5223. OEV's number for this recall is 2025-SRC-05
Notes
Defect #6: Driveshaft Malfunction (MFR Campaign: 2025-SRC-06)
NHTSA ID: 25V571000 | MFR Campaign Number: 2025-SRC-06
Posted on: 2025-09-04
Description
Orange EV (OEV) is recalling certain 2024-2025 HUSK-e Tandem terminal trucks. The driveshaft may contact and damage the passenger side brake chamber or brake chamber bracket.
Consequence
Damaged brake components may cause a reduction of brake performance and unexpected activation of the emergency braking system, increasing the risk of a crash.
Corrective Action
OEV field service will inspect and replace the driveshaft and brake chamber components as necessary, free of charge. Owner notification letters are expected to be mailed November, 2025. Owners may contact OEV customer service at
1-866-688-5223. OEV's number for this recall is 2025-SRC-06
Notes
Defect #7: Thermal Management Malfunction (MFR Campaign: 2025-SRC-04)
NHTSA ID: 25V367000 | MFR Campaign Number: 2025-SRC-04
Posted on: 2025-06-02
Description
Orange EV (OEV) is recalling certain 2023-2025 Husk-e terminal trucks. The high voltage short circuit protection system may have an inadequate fuse.
Consequence
In the event of a short, the fuse may open too slowly or not at all, increasing the risk of a fire.
Corrective Action
OEV will replace the fuse, free of charge. Owner notification letters were mailed June 9, 2025. Owners may contact OEV customer service at
1-866-688-5223. OEV's number for this recall is 2025-SRC-04
Notes
